Furnace Ignition and Pilot Light Repair in Stratton, OH Near Me

Thermostat won't turn the furnace on? Here is what is usually behind it. Blank screen: swap the batteries. If it stays dark, the thermostat has probably lost its 24-volt supply, often from a blown low-voltage fuse on the furnace control board. Screen lit, no heat: confirm it is set to heat and no schedule or hold is overriding it. Make sure the furnace door is seated, since its safety switch cuts power when loose. Look for a tripped condensate float switch too. Stop and get a professional if a replacement fuse blows again. That fuse is a symptom of a short in the thermostat wiring, not a part to keep swapping. If you smell burning or see scorched wire, shut the furnace off at the breaker now. Pre-1990 Stratton, OH homes often lack a common wire, which is why many smart thermostat installs fail. Pro HVAC is a referral service connecting Ohio homeowners with local HVAC pros. Call (321) 463-9811.

A burning smell on first startup in fall is often dust burning off the heat exchanger and may clear after a few hours. Persistent or strong odors can indicate overheating or electrical issues. Turn the thermostat down, switch power off at the breaker, and call (321) 463-9811. Do not keep running the unit in Stratton, OH winter conditions if the smell returns.

Most furnaces last 15 to 20 years with regular filter changes. In Stratton, OH winters, heavy use can shorten life if maintenance is skipped. Watch for increasing repair frequency, uneven heating, or higher energy bills after year 15. A cracked heat exchanger, confirmed only by a qualified technician, requires immediate replacement for safety.

Check the thermostat batteries and confirm the switch is set to heat. Replace the furnace filter if it is dirty, then verify the breaker is on. If the furnace still does not respond, turn the system off at the breaker to prevent further damage. Call (321) 463-9811 for referral to a local technician who can diagnose the issue safely.

Yes, and it is the most common cause of faults that look like equipment failure. A restricted filter makes a furnace overheat and shut down on its limit switch, freezes an air conditioning evaporator coil solid, and makes the blower motor draw high current until it fails early. Two things matter more than brand: the filter must fit its slot tightly, because a loose filter lets air bypass it completely, and a very high MERV rating in a system not designed for it restricts airflow enough to cause the same overheating it was meant to prevent. A filter that darkens within weeks in Stratton, OH usually means duct leakage is pulling in unfiltered air.